I would suspect a corroded connector block. You need to clean as many as you can find. It's a long and boring job but use some ACF-50 or similar stuff to do a good job.
It may be one somewhere near the headstock. I've not checked out the Fazers wiring yet but I had similar problems with an FJ1200.
Quote from: Hugh Mungus on 20 June 2018, 08:52:41 pmIt may be one somewhere near the headstock. I've not checked out the Fazers wiring yet but I had similar problems with an FJ1200.Now that you mentioned it, the bike has been cutting out at full left lock sometimes, and it wasn't the running switch causing it when I checked.
It might not be shorting when turning. It might be "breaking" when turning too
Quote from: BBROWN1664 on 22 June 2018, 11:08:59 amIt might not be shorting when turning. It might be "breaking" when turning tooIt hasn't happened again since I wiggled and reconnected the cables I could find, cleaning out dust etc. But the 8k+ trouble has become worse at times, especially if I go full throttle through the gears it just plutters and foccs around above 8-9k.New filters are on it's way (air and fuel), new regulator (ebay ftw) and a carb repair kit ought to do the trick. A milestone - I've now spent over half the initial price on upgrades and replacement parts
Quote from: Spiffle on 25 June 2018, 07:51:35 pmQuote from: BBROWN1664 on 22 June 2018, 11:08:59 amIt might not be shorting when turning. It might be "breaking" when turning tooIt hasn't happened again since I wiggled and reconnected the cables I could find, cleaning out dust etc. But the 8k+ trouble has become worse at times, especially if I go full throttle through the gears it just plutters and foccs around above 8-9k.New filters are on it's way (air and fuel), new regulator (ebay ftw) and a carb repair kit ought to do the trick. A milestone - I've now spent over half the initial price on upgrades and replacement parts that's about right, you need deep pockets to keep a 15 year old on the road. The 8k+ trouble could be a vac leak if she's running lean, have a look at the condition of the carb rubbers.
Quote from: celticdog on 25 June 2018, 08:50:56 pmQuote from: Spiffle on 25 June 2018, 07:51:35 pmQuote from: BBROWN1664 on 22 June 2018, 11:08:59 amIt might not be shorting when turning. It might be "breaking" when turning tooIt hasn't happened again since I wiggled and reconnected the cables I could find, cleaning out dust etc. But the 8k+ trouble has become worse at times, especially if I go full throttle through the gears it just plutters and foccs around above 8-9k.New filters are on it's way (air and fuel), new regulator (ebay ftw) and a carb repair kit ought to do the trick. A milestone - I've now spent over half the initial price on upgrades and replacement parts that's about right, you need deep pockets to keep a 15 year old on the road. The 8k+ trouble could be a vac leak if she's running lean, have a look at the condition of the carb rubbers.Initial price was just shy of 1600 eur, 32.000km on the clock. But I think it's been converted to 'sport' somewhere along the road, had low bars, smaller windscreen and adjusted rear-brake and gear levers, which I had to adjust after the Renthal 754(?) came on. Does anyone know the stock length of the doglegs? I'm no heavyweight and the spring is at 3/4 hard adjustment. Anyone able to make an internet opinion on if the arse is high? https://i.imgur.com/AiRFhal.jpgIt's booked for a major service, have to do forks and front bearings, it's not great while braking, vibrations etc. New pads, went GG because they adapt to the worn disks - later on those have to be replaced, after this set of pads. They'll flush the tank and service the carbs at the same time.Landed on the DID X ring gold and black, about €125 for a kit with JT sprockets. The current ones might well be original from the sound and looks, but at least the front nut and lock has been changed. Got a new one for that too.Since the shocks have being serviced, I'll be going for 15w instead of 10w - has anyone found this to be uncomfortable? Roads here range from good to scattered spots of asphalt with some gravel on, so while i want to get rid of the ridiculous nosedive while braking maybe mixing to 12,5 would fit better?